|本期目录/Table of Contents|

[1]龚俊,叶俊红,陈亮,等.相渗改善特性减阻剂乳液制备及现场应用[J].断块油气田,2020,27(04):528-532.[doi:10.6056/dkyqt202004025]
 GONG Jun,YE Junhong,CHEN Liang,et al.Preparation of friction reducing emulsion with relative permeability modification and its field application[J].Fault-Block Oil and Gas Field,2020,27(04):528-532.[doi:10.6056/dkyqt202004025]
点击复制

相渗改善特性减阻剂乳液制备及现场应用(PDF)
分享到:

《断块油气田》[ISSN:1005-8907/CN:41-1219/TE]

卷:
27
期数:
2020年04
页码:
528-532
栏目:
默认栏目
出版日期:
2020-07-25

文章信息/Info

Title:
Preparation of friction reducing emulsion with relative permeability modification and its field application
作者:
龚俊1叶俊红1陈亮1罗帅2罗明良2
1.中国石化胜利油田分公司海洋采油厂,山东 东营 257237;2.中国石油大学(华东)非常规油气开发教育部重点实验室,山东 青岛 266580
Author(s):
GONG Jun1 YE Junhong1 CHEN Liang1 LUO Shuai2 LUO Mingliang2
1.Offshore Oil Production Plant, Shengli Oilfield Company Ltd., SINOPEC, Dongying 257237, China; 2.MOE Key Laboratory of Unconventional Oil & Gas Development, China University of Petroleum, Qingdao 266580, China
关键词:
低渗透油藏减阻剂反相乳液聚合相渗改善现场应用
Keywords:
low permeability oil reservoir friction reducer inverse emulsion polymerization relative permeability modification(RPM) field application
分类号:
-
DOI:
10.6056/dkyqt202004025
文献标志码:
A
摘要:
高含水低渗透油藏压裂裂缝效应易导致油井含水率快速上升,常规低摩阻压裂液难以满足控水压裂要求,因此,以丙烯酰胺(AM)、2 ̄丙烯酰胺基 ̄2 ̄甲基丙磺酸(AMPS)和N,N ̄二甲基丙烯酰胺(DMAA)为主要材料,制备了一种具有相渗改善特性的减阻剂乳液(FRA ̄1),同时表征了合成产物主要基团及乳液粒径分布,考察了FRA ̄1的减阻性与相渗改善性能,并在胜利油田进行了现场应用。实验结果表明:合成产物在红外谱图中呈现出3种聚合物单体主要官能团的特征峰;乳液粒径约80 nm,随静置时间增加而增大;质量浓度为10 mg/L的FRA ̄1溶液减阻率可达72.5%,进入储层可降低水相渗透率80%以上,对油相渗透率影响较小。现场应用显示,FRA ̄1具有良好的减阻效果,压裂后油井含水率降低幅度达50%以上,具有良好的应用前景。
Abstract:
Water-cut of oil wells rises rapidly due to the fracture effect in low permeability reservoirs with high water saturation, and conventional low friction fracturing fluids are difficult to meet the requirements of water control fracturing. With acrylamide(AM), 2-acrylamide-2-methyl propane sulfonic acid(AMPS) and N,N-2-methacrylamide(DMAA) as main materials, the friction reducing emulsion(FRA-1) with relative permeability modification was prepared. The main groups and particle size distribution of synthetic product were characterized. The performance of FRA-1 friction reduction and relative permeability modification were investigated, and FRA-1 was also used in Shengli Oilfield. The results show that the characteristic absorption peaks of three polymer monomers in the infrared spectrum confirm the product formation, and the particle size of FRA-1 emulsion is about 80 nm and increases with the standing time. The friction reduction rate of FRA-1 solution by mass concentration of 10 mg/L can reach 72.5%; water phase permeability can be reduced by more than 80%, but oil phase permeability is littlely affected when FRA-1 solution invades the reservoir. In piolt test, FRA-1 possessed good friction reduction effect, and water-cut of oil well decreased by more than 50%, showing good prospect for water control of fractured oil wells.

参考文献/References:

相似文献/References:

[1]张益,陈军斌,石海霞,等.低渗高气油比油井合理套压研究[J].断块油气田,2011,18(03):397.
[2]刘顺,何衡,张华光.基于动态渗透率效应的低渗透油藏产能新观点[J].断块油气田,2011,18(04):482.
[3]封永利.超高压注水井解堵增注技术的研究与应用[J].断块油气田,2005,12(01):71.
 Feng Yongli.The Research and Applica tion of Block Removing by Strong Oxidizer[J].Fault-Block Oil and Gas Field,2005,12(04):71.
[4]汪嘉月. GJ油田细分层高效挖潜技术[J].断块油气田,2005,12(02):41.
 [J].Fault-Block Oil and Gas Field,2005,12(04):41.
[5]殷代印,张 强.朝阳沟油田朝55区块井网加密研究[J].断块油气田,2009,16(02):70.
 Yin Daiyin,Zhang Qiang.Research on well patterns thickening of Block Chao 55 in Chaoyanggou Oilfield[J].Fault-Block Oil and Gas Field,2009,16(04):70.
[6]叶 锋.童氏图版的改进及在油藏含水率预测中的应用[J].断块油气田,2009,16(04):89.
 Ye Feng.Improvement of Tong’s Chart and application in forecasting water cut of reservoir[J].Fault-Block Oil and Gas Field,2009,16(04):89.
[7]赵军胜,钱卫明,郎春艳.苏北低渗透油藏CO2 吞吐矿场试验[J].断块油气田,2003,10(01):73.
 [J].Fault-Block Oil and Gas Field,2003,10(04):73.
[8]付洁,宋国英,韩战江,等.濮67块沙三中6一10低渗透油藏层序地层研究[J].断块油气田,2005,12(05):20.
 [J].Fault-Block Oil and Gas Field,2005,12(04):20.
[9]王进安,曾贤辉,陈德斌,等.低渗透挥发性油藏注烃类气驱室内实验研究[J].断块油气田,2002,09(06):58.
 Wang Jinan,Zeng Xianhui,Chen Debin,et al.The Experiment Study of Hydrocarbon Gas Injection in Low Permeability Volatile Reservoir[J].Fault-Block Oil and Gas Field,2002,09(04):58.
[10]陈民锋,张兴焰,冷 风,等.文东沙三中油藏储层性质对水驱开发规律的影响[J].断块油气田,2001,08(06):35.
 Chen Minfeng,Zhang Xingyan,Leng Feng,et al.Effect on Water Flooding Development Rule of Reservoir Characteristics of the Middle of the Third Section of Shahejie Formation in Wendong Oilfield[J].Fault-Block Oil and Gas Field,2001,08(04):35.

备注/Memo

备注/Memo:
更新日期/Last Update: 2020-07-24